20目干洗店衣服皮毛处理用玉米芯 厂家直销 产地直发

         巩义市万丰磨具磨料有限公司是专业的水处理材料生产厂家，主营产品有三大系列：

       一、喷砂抛光系列：棕刚玉、黑纲玉、白刚玉、碳化硅、石榴石、玉米芯、水刀砂、抛光砂、除锈砂、还原铁粉等。

       二、滤料系列：鹅卵石、麦饭石、沸石、陶粒、磁铁矿、海绵铁等。

       三、耐火材料系列：铝矾土、蓄热球、氧化铝球、高铝球、研磨球、浇注料、耐火泥、铬刚玉、锆刚玉、锆英砂、氧化铬绿、氧化铝粉、球石、漂珠等。

       我公司一直坚持：“品质承诺、价格合理、服务快捷、诚心创新”的发展理念，不仅为客户提供高品质的产品，并努力做好客户的售后服务工作！热诚欢迎国内外宾朋光临，大量现货供应，欢迎订购！

【玉米芯简介】

          玉米芯是选用优质玉米棒破碎加工而成，为米色或黄褐色，具有粒度均匀、硬度适宜、韧性好、吸水性强、耐磨性能好等优点，在使用过程中不易破碎。玉米芯颗粒粉是以往各种粕类颗粒粉的换代产品，含水份5.0、粗蛋白5.7、粗纤维3.7，比重为0.3-0.35，吸附力50-70，是制作兽药的载体，是豆饼粉及其它载体的替代品，主要用于生产马杜霉素、胆碱类、维生素、预混剂和饲料添加剂等十几个兽药及饲料添加剂品种，它具有比其它载体成本低、保质期长、流动性好、吸水性强、适口性好等特点。以玉米芯颗粒粉为载体生产的兽药保质期达三年以上重稳定，各项指标及微生物指标均符合国内和国际标准，成本低、物美价廉。

【玉米芯特点】

       玉米芯做垫料使用具有吸水性强、吸气味佳（ ）、吸臭，吸水性远远超过木屑，几乎粉尘散发、表面干燥、更换次数少、持续时间长、损耗低的特点，适合各种啮齿类动物、仓鼠、熊、龙猫、猫、兔等。

       由于玉米芯中含有大量蛋白质、碳水化合物、无机盐等各种畜禽生长所必需的营养成份，是喂畜的好饲料，现在已经被各大养殖场广泛使用。

【玉米芯的制作方法】

       1、磨碎浸泡：选用当年的玉米芯100千克碾磨成细屑，大小似豆粒为宜，置于浸泡缸中浸泡1～2小时，使玉米芯屑吸水膨胀，吸水量达40%左右。浸泡后将坯料捞出放在竹筐和箩筐中，再用清水冲洗一下，沥水后即可上屉汽蒸。 

       2、汽蒸：上屉蒸制时，先将浸泡过的玉米心屑铺好，上面盖一层麸皮或谷糠，其用量约占坯料的10%，上汽后蒸20分钟，向坯料中拌入10%的凉水，拌匀后再蒸40分钟。再拌入10%的凉水，目的使坯料软化并蒸熟蒸透。 

       3、拌麦芽乳：待蒸好的坯料摊晾至65～75℃时，即可拌入麦芽乳。坯料摊晾温度冬季取高限，夏季取低限。麦芽乳的制作：先将大麦15千克(以当年的二棱大麦为佳)在清水中浸泡2小时，若水温过低，应适当延长浸泡时间，浸过的麦粒平铺在竹匾上，厚1厘米左右，上盖湿布保温25～30℃，直至大麦发芽。当麦芽长到干麦粒的两倍半长，芽苞由白转绿时，加水上磨磨成乳，加水量约为麦芽的1倍。 

       4、糖化：拌入麦芽乳后，即可将坯料下缸糖化，糖化缸应能保温，进行保温糖化16～24小时，进料后糖化温度须保持在55℃左右，后期温度可适当提高。糖化结束后，放出糖液进行浓缩制饴。 

       5、浓缩制饴：将糖化缸底部的浓糖液尽量放出，立即过滤，然后入锅熬糖浓缩。糖糟可作饲料。熬糖时，开始火力要猛，随着糖液的浓缩，火力要逐渐减弱，并不停地搅拌，预防变焦炭化，较后用小火熬制，直至所需要的浓度。100千克玉米芯可制得饴糖约50千克。 

【玉米芯理化指标】

【玉米芯用途】

       1、可用它从废水中提取重金属，可用它防止热的薄刚片粘在一起；

       2、可用于纸板、水泥板、水泥砖制作，可用它做胶水或浆糊的填充剂；

       3、可用做包装材料、的制造；

       4、硬而富有弹性、坚固耐用性，如橡胶、轮胎工业，可用做橡胶助剂，制造轮胎时加入它，可增加轮胎与地面间的磨擦力，达到增大牵引力的效果，延长轮胎使用寿命；

       5、可用于干洗业，用它处理过的皮毛既干净又美观；

       6、可作为饲料预混料，蛋氨酸、赖氨酸、赖氨酸蛋、甜菜碱、各种霉制剂、防霉剂、维生素、磷脂、植酸酶、香味剂及马杜酶素、安普酶素氯化胆碱等，兽药添加剂产品，营养性载体，可代替次粉，也是生物制品水洗霉发酵的主要原料之一；

       7、磨擦性:可用来擦拭、磨光、干燥金属或塑料、玻璃等制品；

       8、吸附性:可吸收四倍于它自重的液体，是一种很有发展的活性碳资源。它用于湿的有水的运动场地的吸收、干燥、原子核废料及化学废料的吸收，大面积水域表面油污的清理；

       9、无毒性:用于饲料工业维生素、调味品的载体；

     10、化学稳定性:它是一种极好医药、化工载体；

     11、生物可降解性:对环境不造成污染。

     12、宠物垫料

【玉米芯规格及包装】

       规格：4 5 6 8 10 12 14 16 20 24 30 36 46 60目

       包装：25kg双层编织袋包装，吨包装。

【英文翻译】

 【 Cod Summary 】
Corn cob and broken and corn cob is selection of quality for cream-colored or yellow-brown, with uniform particle size, suitable hardness, good toughness, strong water imbibition, wear-resisting performance is good wait for an advantage, in use process is not easy to break.Corn cob powder particles is the replacement of the past all sorts of wheat class granular powder, water cut of 5.0, crude protein, crude fiber, 5.7 5.7, the proportion of 0.3 0.35, the adsorption capacity of 50-70, is a production of veterinary drugs carrier, carrier is bean cake powder and other alternatives, mainly for the production of madurai, doxycycline, choline, vitamin, premix and feed additives and so on more than a dozen varieties of veterinary drugs and feed additives, it has a lower cost than other carrier, long shelf life, good liquidity, water imbibition is strong, good palatability.As a carrier for the corn cob granule powder production of veterinary drugs shelf life for three years for stability, various indexes and microbial indexes meet the domestic and international standards, low cost, good and inexpensive.
【 cod characteristics 】
Corn cob bedding use with strong water imbibition, suction is excellent (ammonia), smelly, far more than water imbibition of sawdust, almost dust distribution, surface drying, fewer replacement, the characteristics of long duration, low dissipation, suitable for all kinds of rodents, hamster, bear, my neighbor totoro, cats, rabbits and so on.
Because the corn cob is contained in a large number of proteins, carbohydrates, inorganic salt and other necessary nutrition, animal growth is a good feed livestock feed, now has been widely used by each big farms.
【 The method of making the raw 】
1, grinding soaking: choose the 100 kg of cod grinding into fine scales, size pea advisable, placed in the water soak 1 ~ 2 hours in the cylinder, make the corn cob crumbs swell, water quantity of 40% or so.After soaking scoop out the blank in the bamboo basket and bundle, reoccupy clear water rinse, the drawer steam after waterlogging caused by excessive rainfall. 
2, steaming: drawer steamed, first soaked corn crumbs lay good heart, will be covered with a layer of bran and bran, its consumption accounts for about 10% of the billet, saic and steam for about 20 minutes, to stir in 10% of the water in the blank, mix well after another 40 minutes of steaming.Stir in 10% of the cold water again, the purpose to soften billet and steamed steamed. 
3, malted milk: mixing with steamed billet stand out to 65 ~ 75 ℃, then stir in malted milk.Blank booth take high limit air temperature in winter, summer low limit.Malted milk production: first the barley 15 kg (in the two edges of the barley is preferred) in clean water for 2 hours, if the water temperature is too low, should be appropriately extended soak time, soaked in flat out on the ZhuBian grains, 1 cm thick, covered with wet cloth insulation 25 ~ 30 ℃, until the barley sprout.When wheat malt grow to dry the two and a half times as long, bud from white to green, the water on the slow into milk, water content is about 1 times of malt. 
After 4, saccharification, stir in wheat germ milk, the billet can be cylinder saccharification, saccharifying tank should be able to heat preservation, heat preservation saccharification 16 ~ 24 hours, after feed saccharification temperature must remain at about 55 ℃, the late temperature can be appropriately increased.After saccharification, release sugar liquid syrup for enrichment. 
5, concentrated syrup: saccharification cylinder at the bottom of the thick liquid sugar out as far as possible, immediately filter, and then into the pot boil sugar concentration.Sugar is bad for feed., start fire to boil sugar, with the concentration of sugar solution, firepower to wane, do not stop stirring, prevent zoom carbonization, with small fire boil, finally until the required concentration.100 kg corn cobs can be obtained caramel about 50 kilograms.

"Corn cobs purposes"
1, available extraction of heavy metals from wastewater, it can use it to prevent hot stalloy stick together;
2, can be used in the paper, cement, cement brick production, can use it to glue or paste filling agent;
3, can be used as packaging materials, the manufacture of powder;
4, hard and full of elasticity, durable sex, such as rubber, tire industry, rubber additives are available, and tires to join it, can increase the friction between the tire and ground, increasing the effect of traction, prolong the service life of tires;
5, can be used for the dry cleaning industry, with its treated fur is clean and beautiful.
6, can be used as feed premix, methionine, lysine, lysine protein powder, betaine, all kinds of mould preparation, fungicide, vitamin, phospholipids, phytase, fragrances and madurai, enzyme and ample enzyme, choline chloride, etc., veterinary medicine additive products, nutritional carrier, can replace powder, it is also one of biological products the main raw material of water mildew fermentation;
7, friction: can be used to cleaning, polishing, drying metal or plastic, glass and other products;
8, adsorption, absorption of four times its weight of the liquid, is a development of activated carbon resource.It is used for wet with water absorption of the sports venues, drying, atomic nuclear waste and the absorption of chemical waste, large area water surface greasy dirt clean;
9, non-toxic, the carrier of vitamin, spices used in the feed industry;
Ten, chemical stability, it is a kind of very good medicine, chemical carrier;
11, biodegradable: don't cause pollution to the environment.
12, pet bedding
【 Cod Specifications and packing 】
Specification: 4 5 6 8 10 12 14 16 20 and 24 30 36 46 60 mesh
Packing: packed in 25 kg double bag, tons of packaging.

【联系方式】

  公司名称：巩义市万丰磨具磨料有限公司

  公司地址：河南省巩义市建设路

  联系人：郑经理

  联系电话： 

  传 真：

  Q  Q: 3075794110

 【产品展示】

【包装展示】

【厂区实拍】

【发货现场】